Kia Forte: Oil Pump Unit (OPU) Inspection - ISG (Idle Stop & Go) System - Engine Control / Fuel System - Kia Forte TD 2014-2018 Service ManualKia Forte: Oil Pump Unit (OPU) Inspection

Second generation YD (2014-2018) / Kia Forte TD 2014-2018 Service Manual / Engine Control / Fuel System / ISG (Idle Stop & Go) System / Oil Pump Unit (OPU) Inspection

OPU Problem Inspection Procedure
1.
TEST OPU GROUND CIRCUIT: Measure resistance between OPU and chassis ground using the backside of OPU harness connector as OPU side check point. If the problem is found, repair it.

Specification: Below 1Ω

2.
TEST OPU CONNECTOR: Disconnect the OPU connector and visually check the ground terminals on OPU side and harness side for bent pins or poor contact pressure. If the problem is found, repair it.
3.
If problem is not found in Step 1 and 2, the OPU could be faulty. If so, make sure there were no DTC's before swapping the OPU with a new one, and then check the vehicle again. If DTC's were found, examine this first before swapping OPU.
4.
RE-TEST THE ORIGINAL OPU: Install the original OPU (may be broken) into a known-good vehicle and check the vehicle. If the problem occurs again, replace the original OPU with a new one. If problem does not occur, this is intermittent problem (Refer to “Intermittent Problem Inspection Procedure” in Basic Inspection Procedure
  
Refer to DTC manual code “P1775, P1777” to inspect oil pump unit.
Oil Pump Unit (OPU) Installation
1. Install in the reverse of removal. ...

Brake Switch Description
The present brake switch is used as an input variable for the ISG function to detect bracke operation. ...

See also:

TJ Joint Replacement
   • Special grease must be applied to the driveshaft joint. Do not substitute with another ...

Accelerator Pedal Removal
1. Turn the ignition switch OFF and disconnect the negative (-) battery cable. 2. Disconnect the accelerator position sensor connector (A). ...

Front Washer Motor Installation
1. Install the washer reservoir.    Before installing the pump motor, check ...

Copyright © www.kifomanual.com 2014-2024