Kia Optima Manuals

Kia Forte: Specification - Engine Electrical System - Kia Forte TD 2014-2018 Service ManualKia Forte: Specification

Second generation YD (2014-2018) / Kia Forte TD 2014-2018 Service Manual / Engine Electrical System / Specification

Ignition System
Ignition Coil
Item
 Specification
Primary Coil Resistance (Ω)
 0.75 ± 15％ [20°C (68°F)]
Secondary Coil Resistance (kΩ)
 5.9 ± 15％ [20°C (68°F)]

Spark plug
Item
 Specification
Type
 SILZKR7B11
Gap
 1.0 ~ 1.1
(0.0394 ~ 0.0433)

Condenser
Item
 Specification
Capacitance (uF)
 0.47 [1KHz]
Insulation resistance (MΩ)
 1,000 [DC 500 V/1 Min]

Charging System
Alternator [Non-ISG type]
Item
 Specification
Rated voltage
 13.5V, 90A
Speed in use
 1,000 ~ 18,000 rpm
Voltage regulator
 IC Regulator built-in type
Regulator Setting Voltage
 External mode
 Refer to below graph
Internal mode
 14.55 ± 0.3V
Temperature Gradient
 External mode
 0 ± 3 mV / °C　
Internal mode
 -3.5 ± 2mV / °C

※ Regulator Setting Voltage (External mode)
Alternator [ISG type]
Item
 Specification
Rated voltage
 13.5V, 120A
Speed in use
 1,000 ~ 18,000 rpm
Voltage regulator
 IC Regulator built-in type
Regulator Setting Voltage
 External mode
 Refer to below graph
Internal mode
 14.55 ± 0.3V
Temperature Gradient
 External mode
 0 ± 3 mV / °C
Internal mode
 -3.5 ± 2mV / °C

※ Regulator Setting Voltage (External mode)
Battery [Non-ISG type]
Item
 Specification
Model type
 CMF60L-DIN
Capacity [20HR / 5HR] (AH)
 60 / 48
Cold Cranking Amperage (A)
 550 (SAE) / 440 (EN)
Reserve Capacity (Min)
 92

AGM Battery [ISG type]
Item
 Specification
Model type
 AGM 70L-DIN
Capacity [20HR / 5HR] (AH)
 70 / 56
Cold Cranking Amperage (A)
 760 (SAE) / 610 (EN)
Reserve capacity (Min)
 120

  
•
Model type description
•
Cold Cranking Ampere (CCA): Cold Cranking Amps is a rating used in the battery industry to define a battery's ability to start an engine in cold temperatures.
-
The rating is the number of amps a new, fully charged battery can deliver at -18 °C(-0.4 °F) for 30 seconds, while maintaining a voltage of at least 7.2 volts for a 12 volt battery.
-
The higher the CCA rating, the greater the starting power of the battery.
•
RESERVE CAPACITY (RC) : Reserve Capacity is a battery industry rating, defining a battery's ability to power a vehicle with an inoperative alternator or fan belt.
-
The rating is the number of minutes a battery at 26.7 °C(80 °F) can be discharged at 25 amps and maintain a voltage of 10.5 volts for a 12 volt battery.
-
The higher the reserve rating, the longer your vehicle can operate should your alternator or fan belt fail.
Starting System
Starter [Non-ISG type]
Item
 Specification
Rated voltage
 12 V, 1.2 kW
The number of pinion teeth
 13
Performance
[No-load, 11 V]
 Ampere
 Max. 70 A
Speed
 Min. 2,400 rpm

Starter [ISG type]
Item
 Specification
Rated voltage
 12 V, 1.4 kW
The number of pinion teeth
 15
Performance
[No-load, 11.5 V]
 Ampere
 Max. 100 A
Speed
 Min. 1,915 rpm

Engine Electrical System
...

Tightening Torques
Item N.m kgf.m lb-ft Ignition coil installation bolt 9.8 ~ 11.8 1.0 ~ 1.2 7.2 ~ 8.7 Spark plug installation 14.7 ~ 24. ...

See also:

Room Lamp Inspection
Room Lamp 1. Check that the switch operates properly after disconnecting the room lamp connector (A). ...

Photo Sensor Replacement
1. Disconnect the negative (-) battery terminal. 2. With a flat-head screwdriver, remove the photo sensor (A) from the center of the defros ...

Rear Coil Spring Replacement
1. Loosen the wheel nuts slightly. Raise the vehicle, and make sure it is securely supported. 2. Remove the front wheel and tire (A) from f ...

Categories


Copyright © www.kifomanual.com 2014-2024